Toyota Tacoma manuals

Toyota Tacoma 2015-2018 Service Manual: Installation

INSTALLATION

CAUTION / NOTICE / HINT

HINT:

  • Use the same procedure for both the RH and LH sides.
  • The procedure described below is for the LH side.

PROCEDURE

1. INSTALL CURTAIN SHIELD AIRBAG ASSEMBLY

(a) Insert the 5 hooks, install 6 new bolts, 2 new clips with pins and 2 new spacers to install the curtain shield airbag assembly.

Text in Illustration

*1

Clip

*2

Spacer

*a

Pin

*b

Hook

Torque:

12.5 NВ·m {127 kgfВ·cm, 9 ftВ·lbf}

NOTICE:

Do not twist the curtain shield airbag assembly.

(b) Connect the connector

NOTICE:

When handling the airbag connector, take care not to damage the airbag wire harness.

(c) Push in the airbag connector lock to install the airbag connector.

2. INSTALL ROOF HEADLINING ASSEMBLY

Click here 3. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL

3. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL

Torque:

5.4 NВ·m {55 kgfВ·cm, 48 inВ·lbf}

NOTICE:

When disconnecting the cable, some systems need to be initialized after the cable is reconnected.

Click here 4. INSPECT SRS WARNING LIGHT

4. INSPECT SRS WARNING LIGHT

Click here Removal

Disposal
DISPOSAL CAUTION / NOTICE / HINT CAUTION: Before performing pre-disposal deployment of any SRS part, review and closely follow all applicable environmental and hazardous material regulations. Pre ...

Removal
REMOVAL CAUTION / NOTICE / HINT HINT: Use the same procedure for both the RH and LH sides. The procedure described below is for the LH side. PROCEDURE 1. PRECAUTION CAUTION: B ...

Other materials:

How To Proceed With Troubleshooting
CAUTION / NOTICE / HINT HINT: Use the following procedure to troubleshoot the manual transaxle system. *: Use the Techstream. PROCEDURE 1. VEHICLE BROUGHT TO WORKSHOP NEXT ...

Installation
INSTALLATION CAUTION / NOTICE / HINT HINT: The following procedures are for BD20 (w/o Differential Lock). PROCEDURE 1. INSTALL REAR DIFFERENTIAL CARRIER ASSEMBLY (a) Clean the contact surfaces of the rear differential carrier assembly and axle housing. (b) Install the rear differ ...

Components
COMPONENTS ILLUSTRATION *1 RADIATOR GRILLE - - ILLUSTRATION *A for Type A *B for Type B *C for Type C - - *1 MILLIMET ...

2015-2022 © Copyright www.luting.site